| NHTSA Campaign Number: |
01V080000 |
| Vehicle/Equipment Make: |
CHEVROLET |
| Vehicle/Equipment Model: |
C SERIES (MEDIUM) |
| Model Year: |
2001 |
| Manufacturer Campaign Number: |
1019 |
| Manufacturer Component Description: |
FUEL SYSTEM, OTHER |
| Manufacturers Involved in Recall: |
GENERAL MOTORS CORP. |
| Manufacturered: |
20001201 - 20010331 |
| Type of Report: |
V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: |
187 |
| Date Owner Notified By Manufacturer: |
20010521 |
| Recall Initiated By: |
20010521 |
| Manufacturer Responsible For Recall: |
GENERAL MOTORS CORP. |
| Report Received Date: |
20010309 |
| Record Creation Date: |
20010321 |
| Regulation Part Number: |
|
| Federal Motor Vehicle Safety Standard Number: |
|
| Defect Summary: |
VEHICLE DESCRIPTION: MEDIUM DUTY C SERIES VEHICLES EQUIPPED WITH AN IMPCO LIQUEFIED PETROLEUM GAS (LPG) CONVERSION KIT. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE ENGINE COULD BACKFIRE AND FRACTURE THE PLASTIC INLET ELBOW WITHIN THE ENGINE COMPARTMENT. |
| Consequence Summary: |
IF THIS WERE TO OCCUR, AND THE HOOD OF THE VEHICLE WERE OPEN, PLASTIC FRAGMENTS FROM THE ELBOW COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. IN ADDITION, THE VEHICLE WILL STOP RUNNING DUE TO INADEQUATE FUEL SUPPLY. |
| Corrective Summary: |
DEALERS WILL INSTALL A TEMPORARY INLET ELBOW THAT IS REINFORCED WITH A FIBERGLASS WRAP. THE INSTALLATION OF THIS TEMPORARY ELBOW WILL ELIMINATE THE SAFETY CONDITION. FOR THE PERMANENT REPAIR, DEALERS WILL INSTALL ALUMINUM INLET ELBOWS. A PRELIMINARY OWNER NOTIFICATION WAS MAILED TO CONSUMERS DURING MAY 2001. OWNER NOTIFICATION BEGAN MAY 21, 2001. A SEPARATE OWNER NOTIFICATION WILL BE MAILED WHEN PARTS ARE AVAILABLE FOR THE PERMANENT REPAIR. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. |
